Our Products
Thermoplastic materials are susceptible to ultraviolet (UV) degradation upon prolonged exposure to sunlight. Evidence of such degradation could be observed as a color change. The rate at which degradation may occur varies based on the availability of air, water, oxygen and other oxidizing agents.
The use of black pigment in fusion UV pipes will improve weathering characteristics by helping to screen out the ultraviolet light. Pigments are incorporated into the resin system to act as a further barrier to UV penetration into the laminate.
Since UV degradation is a surface phenomenon the most efficient means of prolonging the integrity of the reinforcement it to place a resin-rich protective layer on the surface of the pipe. On account of this, fusion UV pipes are over-wrapped with an organic barrier layer to provide even greater UV resistance.
PIPE PN-10 | PIPE PN-16 | PIPE PN-20 |
20mm | 20mm | 20mm |
25mm | 25mm | 25mm |
32mm | 32mm | 32mm |
40mm | 40mm | 40mm |
50mm | 50mm | 50mm |
63mm | 63mm | 63mm |
75mm | 75mm | 75mm |
90mm | 90mm | - |
110mm | 110mm | - |
160mm | - | - |
PPR pipes are manufactured from Polypropylene Random Copolymer raw material. The most important feature of PPR that distinguishes it from the others is that it could also be used in hot water systems besides being used in sanitary networks.
APPLICATIONS AND INSTALLATIONS
The product is used at the sanitary lines of the buildings. Because of its endurance against hot water it could be used in heating systems and their state without the folio is not recommended. Momentary pressure and temperature rises may cause the pipe to explode. For these conditions Oxy-stable pipe with folio should be used.
Products are installed to the buildings according to the diameters given by the engineers. They are installed under coat or ground. The pipes are produced in 4 m lengths. With any type of fittings it could be connected with socket welding. For the transitions with the metal parts on the line fittings with metal parts are used.
Could be used in sun collector, too. Since the pressure is low at the system though it is affected by the sun, no problem occurs.
When the water inside the pipe gets frozen it doesn't exploit due to its stretching ability. However, the ice compresses the pressurized water inside the pipe as its volume increases. This compression can reach 80 bars momentarily. In this case the pipe may explode because of the pressure of the water. IMPORTANT POINTS
PRODUCT LIFE It is guaranteed for 50 years under working conditions of 20°C and 25 bars. When the fluid is hot, depending on its temperature and pressure value of usage could be obtained from the table.